Expression of Snow Flea (Hypogastrura harveyi) Antifreeze Protein HhAFP in Pichia pastoris and Its Antifreeze Effect
ZHONG Wen-Qian1, YAN Qian-Qian1, HU Rui-Qin1, CHEN Liang-Biao1,2*
1 College of Fisheries and Life Science, Shanghai Ocean University, Shanghai 201306, China; 2 Center for Aquacultural Breeding Research/Key Laboratory of Exploration and Utilization of Aquatic Resources, Ministry of Education/International Research Center for Marine Biological Sciences, Shanghai Ocean University, Shanghai 201306, China
Abstract Antifreeze proteins (AFPs) are a type of macromolecular proteins that can bind to the surface of ice crystals to inhibit the growth of ice crystals. Pichia pastoris is a system that can express foreign proteins. It can use methanol as a carbon source to express the target protein. In order to obtain high-yield active antifreeze protein, the insect snow flea (Hypogastrura harveyi) antifreeze protein (HhAFP) was selected. XhoⅠ and XbaⅠ restriction sites were added to the 5' end and 3' end of the target gene through PCR. 6×His tag was added to the 3' end of the target gene that could be used for identification and screening. The target gene was added to the expression vector pPICZαA suitable for the P. pastoris expression system through transformation, and the recombinant expression vector pPICZαA-HhAFP was successfully constructed. pPICZαA-HhAFP was transformed into P.pastoris expression strain X-33 by electroporation, and cultured in a 29 ℃ incubator until positive yeast transformants grew. Two positive yeast transformants were then screened out using bleomycin (zeocin) and methanol. The expression of these 2 yeast strains was induced and cultured for 72 h using BMM medium containing 1% methanol at 29 ℃, 250 r/min, and pH 6.0. The yeast supernatant was purified using affinity chromatography, and the obtained purified product was dialyzed and concentrated. It was analyzed by matrix-assisted laser desorption/ionization time of flight mass spectrometry (MALDI-TOF/TOF) to verify that the protein was the recombinant protein HhAFP. The recombinant protein HhAFP was added to the cell cryopreservation solution to test its antifreeze activity. The results proved that HhAFP could significantly improve the survival rate of cells after cryopreservation and reduce cell damage. By further optimizing the expression conditions of HhAFP, the culture temperature was determined to be 28 ℃ and the methanol concentration was 1.5%. The recombinant protein HhAFP obtained after 72 h of expression and culture could reach 527 mg/L. This study provides a technical approach for the high-yield expression of active antifreeze proteins by P. pastoris and the industrialization of antifreeze proteins.
ZHONG Wen-Qian,YAN Qian-Qian,HU Rui-Qin, et al. Expression of Snow Flea (Hypogastrura harveyi) Antifreeze Protein HhAFP in Pichia pastoris and Its Antifreeze Effect[J]. 农业生物技术学报, 2024, 32(12): 2848-2858.
[1] 李凤芝, 张是敬. 1995. 冻伤发病机理的研究进展[J]. 解放军预防医学杂志, (05): 416-418. (Li F Z, Zhang S J. 1995. Research progress on the pathogenesis of frostbite[J]. Journal of Preventive Medicine of the People's Liberation Army, (05): 416-418.) [2] 付艳霞, 黄巧, 陈良标. 2017. 鳞头犬牙南极鱼卵壳蛋白的功能初步研究[J]. 生物学杂志, 34(06): 28-31, 36. (Fu Y X, Huang Q, Chen L B.2017. A preliminary study on the function of eggshell protein of the Antarctic dendrodontodon[J]. Journal of Biology, 2017, 34(06): 28-31, 36.) [3] 郭美锦, 朱泰承, 张明, 等. 2007. 重组毕赤酵母甲醇利用表型与基因拷贝数对外源基因表达的影响[J]. 中国生物工程杂志, (07): 7-11. (Guo M J, Zhu T C, Zhang M, et al. Effect of recombinant Pichia pastoris methanol utilization phenotype and gene copy number on exogenous gene expression[J]. China Biotechnology Journal, (07): 7-11.) [4] 李亚平, 刘丽娟. 2012. 几种昆虫抗冻蛋白的研究概况[J]. 中华卫生杀虫药械, 18(05): 440-443. (Li Y P, Liu L J.2012. Research overview of several insect antifreeze proteins[J]. Zhonghua Sanitary Insecticides, 18(05): 440-443.) [5] 齐连权, 陈薇, 来大志, 等. 2002. 毕赤酵母表达系统研究进展[J]. 中国生物工程杂志, (06): 45-47. (Qi L Q, Chen W, Lai D Z, et al. 2002. Research progress of Pichia pastoris expression system[J]. China Biotechnology Journal, (06): 45-47.) [6] 汪少芸, 赵珺, 吴金鸿, 等. 2011. 抗冻蛋白的研究进展及其在食品工业中的应用[J]. 北京工商大学学报(自然科学版), 29(04): 50-57. (Wang S Y, Zhao J, Wu J H, et al.2011. Research progress of antifreeze proteins and their application in food industry[J]. Journal of Beijing Technology and Business University (Natural Science Edition), 29(04): 50-57.) [7] 许强华, 陈良标. 2021. 南极鱼类适应低温的分子进化研究进展[J]. 大连海洋大学学报, 36(02): 177-186. (Xu Q H, Chen L B.2021. Advances in molecular evolution of antarctic fish adaptation to low temperature[J]. Journal of Dalian Ocean University, 36(02): 177-186.) [8] Barker J R, Haws M J, Brown R E, et al.1997. Magnetic resonance imaging of severe frostbite injuries[J]. Annals of Plastic Surgery, 38(3): 275-279. [9] Baust J G, Gage A A.2005. The molecular basis of cryosurgery[J]. BJU International, 95(9): 1187-1191. [10] Boroda A V, Kipryushina Y O, Yakovlev K V, et al.2016. The contribution of apoptosis and necrosis in freezing injury of sea urchin embryonic cells[J]. Cryobiology, 73(1): 7-14. [11] Bourne M H, Piepkorn M W, Clayton F, et al.1986. Analysis of microvascular changes in frostbite injury[J]. The Journal of Surgical Research, 40(1): 26-35. [12] Cao L, Huang Q, Wu Z, et al.2016. Neofunctionalization of zona pellucida proteins enhances freeze-prevention in the eggs of Antarctic notothenioids[J]. Nature Communications, 7: 12987. [13] Chen L B, Devries A L, Cheng C H C.1997. Convergent evolution of antifreeze glycoproteins in Antarctic notothenioid fish and Arctic cod[J]. Proceedings of the National Academy of Sciences of the USA, 94(8): 3817-3822. [14] Cheng C H, Cziko P A, Evans C W.2006. Nonhepatic origin of notothenioid antifreeze reveals pancreatic synthesis as common mechanism in polar fish freezing avoidance[J]. Proceedings of The National Academy of Sciences of the USA, 103(27): 10491-10496. [15] Davies P L, Baardsnes J, Kuiper M J, et al.2002. Structure and function of antifreeze proteins[J]. Philosophical Transactions of the Royal Society B-Biological Sciences, 357(1423): 927-935. [16] Erinjeri J P, Clark T W I.2010. Cryoablation: Mechanism of action and devices[J]. Journal of Vascular and Interventional Radiology, 21(8): S187-S191. [17] Ewart K V, Lin Q, Hew C L.1999. Structure, function and evolution of antifreeze proteins[J]. Cellular and Molecular Life Sciences, 55(2): 271-283. [18] Fletcher G L, Hew C L, Davies P L.2001. Antifreeze proteins of teleost fishes[J]. Annual Review of Physiology, 63: 359-390. [19] Gauthier S Y, Kay C M, Sykes B D, et al.1998. Disulfide bond mapping and structural characterization of spruce budworm antifreeze protein[J]. European Journal of Biochemistry, 258(2): 445-453. [20] Graether S P, Kuiper M J, Gagne S M, et al.2000. Beta-helix structure and ice-binding properties of a hyperactive antifreeze protein from an insect[J]. Nature, 406(6793): 325-328. [21] Graham L A, Davies P L.2005. Glycine-rich antifreeze proteins from snow fleas[J]. Science, 310(5747): 461-461. [22] Heisig M, Mattessich S, Rembisz A, et al.2015. Frostbite protection in mice expressing an antifreeze glycoprotein[J]. the Public Library of Science One, 10(2): e0116562. [23] Jia Z C, Davies P L.2002. Antifreeze proteins: An unusual receptor-ligand interaction[J]. Trends in Biochemical Sciences, 27(2): 101-106. [24] Khan M, Ibrahim S, Adamu A, et al.2020. Pre-grafting histological studies of skin grafts cryopreserved in α helix antarctic yeast oriented antifreeze peptide (Afp1m)[J]. Cryobiology, 92: 26-33. [25] Kong H, Hong Y, Lee J, et al.2021. Antifreeze protein supplementation during the warming of vitrified bovine ovarian tissue can improve the ovarian tissue quality after xenotransplantation[J]. Front Endocrinol (Lausanne), 12: 672619. [26] Korpan N N.2007. Cryosurgery: Ultrastructural changes in pancreas tissue after low temperature exposure[J]. Technology in Cancer Research & Treatment, 6(2): 59-67. [27] Lee H H, Lee H J, Kim H J, et al.2015. Effects of antifreeze proteins on the vitrification of mouse oocytes: Comparison of three different antifreeze proteins[J]. Human Reproduction, 30(9): 2110-2119. [28] Lin F H, Graham L A, Campbell R L, et al.2007. Structural modeling of snow flea antifreeze protein[J]. Biophysical Journal, 92(5): 1717-1723. [29] Liou Y C, Tocilj A, Davies P L, et al.2000. Mimicry of ice structure by surface hydroxyls and water of a beta-helix antifreeze protein[J]. Nature, 406(6793): 322-324. [30] Mcgann L E, Yang H Y, Walterson M.1988. Manifestations of cell damage after freezing and thawing[J]. Cryobiology, 25(3): 178-85. [31] Notman R, Noro M, O'malley B, et al.2006. Molecular basis for dimethylsulfoxide (DMSO) action on lipid membranes[J]. Journal of the American Chemical Society, 128(43): 13982-13983.
