|
|
|
| Process Optimization of High-density Cultivating Spirulina platensis in a Flat Photobioreactor |
|
|
|
|
Abstract Spirulina is cultivated worldwide, used as a dietary supplement as well as a whole food, and is also available in tablet, flake and powder form. It is significant to improve the production capacity of Spirulina by optimization of production process. A biological reactor has a tank with an interior for growing the biological mass, and application of photobioreactor on high density culture of microalgae has become a hot spot in the domestic and foreign studies. The main economic spirulina is Spirulina platensis and S. maxima, however, S. platensis is the main Spirulina cultured in China. In this study, S. platensis was cultured by triangular flask and flat plate photobioreactor, and different culture conditions (concentration of glucose and antioxidants, and modes of ventilation and illumination) were designed to study the optimization of manufacture process. Results showed that adding glucose, Na2S2O3 and Na2SO3 to triangular flasks separately could significantly improve the algae biomass, and its optimal concentration was 3, 3 and 2 g/L, respectively. Under algae culture in flat plate photobioreactor, the biomass of algae was increased significantly with the increase of aeration intensity from 100 to 800 L/h, however, algae biomass improvement was more obvious under the treatment of gradually increasing aeration intensity from 100 L/h to 800 L/h. Algae biomass cultured by single-side light (4 500 lx) was obviously more than that cultured by double-side light (9 000 lx), and significantly less than that cultured by first single-side light and then double-side light at algae entering into logarithmic phase. The combination effect of Na2SO3 and glucose on algae biomass was better than that of Na2S2O3 and glucose. Further optimization of the above-mentioned conditions suggested that the algae biomass achieved the peak values under 4 g/L glucose and 3 g/L Na2SO3. Generally, adding glucose, Na2SO3, gradually increasing aeration intensity and illumination mode of the double side light source after the first one side light source increased algae production of S. platensis significantly. Under the condition of comprehensive optimization, the algae average growth rate and biomass production could be as high as 0.85 gDW/(L·d) and 10.02 gDW/L, respectively. Moreover, this photobioreactor had several advantages. That is small power consumption, small occupation area, relatively cheap cost, easy cleaning, simple structure, easy scale cultivation in room, etc. This culture technology can provide the theory basis and the technical method for scale cultivation of Spirulina.
|
|
Received: 18 August 2015
Published: 05 February 2016
|
|
|
| Fund:The National High Technology Research and Development Program of China |
|
|
|
| [1]李恺, 孙宝盛, 范艳明, 等.污泥停留时间对除磷效果及酸杆菌群落结构的影响[J].农业生物技术学报, 2015, 23(5):643-651
[2]谯顺彬, 迟海洋, 张义明, 等.螺旋藻混合营养培养基响应面法的优化研究[J].食品科学, 2009, 30(7):109-113
[3]田华, 于斐, 汪金萍.葡萄糖对螺旋藻生长的影响及机理分析[J].食品研究与开发, 2012, 33(7):161-163
[4]田华, 赵琪, 张义明.抗氧化剂对螺旋藻生长的影响研究[J].化学与生物工程, 2006, 23(1):37-38
[5]田华, 张义明.抗氧化剂对螺旋藻流加培养的影响.[J].食品科技,, 2008,, (7):167-168
[6]王长海, 鞠宝, 欧阳藩.光照与培养密度对螺旋藻生长的影响[J].化工冶金, 1999, 20(4):371-375
[7]Cheirsilp B, Torpee S.Enhanced growth and lipid production of microalgae under mixotrophic culture condition: Effect of light intensity, glucose concentration and fed-batch cultivation.[J].Bioresource Technology,, 2012, 110:510-516
[8]Chen C Y, Kao P C, Tsai C J, et al.Engineering strategies for simultaneous enhancement of C- phycocyanin production and CO2 fixation with Spirulina platensis. [J].Bioresource Technology,, 2013,, 145:307-312
[9]Chethana S, Nayak C A, Madhusudhan M C, et al.Single step aqueous two-phase extraction for downstream processing of C-phycocyanin from Spirulina platensis[J].Journal of Food Science and Technology-Mysore, 2015, 52(4):2415-2421
[10]Fan L H, Zhang Y T, Cheng L H, et al.Optimization of carbon dioxide fixation by Chlorella vulgaris cultivated in a membrane- photobioreactor[J].Chemical Engineering and Technology, 2007, 30(8):1094-1099
[11]Ferreira L S, Rodrigues M S, Carvalho J C M, et al.A new approach to ammonium sulphate feeding for fed-batch Arthrospira (Spirulina) platensis cultivation in tubular photobioreactor[J].Biotechnology Progress, 2010, 26(5):1271-1277
[12]Forjan E, Navarro F, Cuaresma M et al.Microalgae: Fast-growth sustainable green factories[J].Critical Reviews in Environmental Science and Technology, 2015, 45(16):1705-1755
[13]Hu D W, Li L, Li Y C, et al.Gas equilibrium regulation by closed-loop photo bioreactor built on system dynamics, fuzzy inference system and computer simulation.[J].Computers and Electronics in Agriculture,, 2014, 103:114-121
[14]Hu D W, Zhang H K, Zhou R, et al.Controller development of photo bioreactor for closed-loop regulation of O2 production based on ANN model reference control and computer simulation. [J].Acta Astronautica,, 2013,, 83:232-238
[15]Kong WB, Song H, Cao Y T, et al.The characteristics of biomass production,lipid accumulation and chlorophyll biosynthesis of Chlorella vulgaris under mixotrophic cultivation[J].African Journal of Biotechnology, 2011, 55(10):11620-11630
[16]Kong W B, Yang H, Cao Y T, et al.Effects of glycerol and glucose on the enhancement of biomass,lipid and soluble carbohydrate production by Chlorella vulgaris in mixotrophic culture[J].Food Technology and Biotechnology, 2013, 51(1):62-69
[17]Kulshreshtha A, Zacharia A J, Jarouliya U, et al.Spirulina in health care management[J].Current Pharmaceutical Biotechnology, 2008, 9(5):400-405
[18]Lodi A, Binaghi L, De Faveri D, et al.Fed-batch mixotrophic cultivation of Arthrospira (Spirulina) platensis (Cyanophycea) with carbon source pulse feeding[J].Annals of Microbiology, 2005, 55(3):181-185
[19]Markou G, Vandamme D, Muylaert K.Microalgal and cyanobacterial cultivation: The supply of nutrients. [J].Water research, 2014, 65:186-202
[20]Mazo V K, Gmoshinski I V, Zilova I S.Microalgae Spirulina in human nutrition[J].Voprosy Pitaniia, 2004, 73(1):45-53
[21]Ra C H, Kang C H, Kim N K, et al.Cultivation of four microalgae for biomass and oil production using a two-stage culture strategy with salt stress.[J].Renewable Energy,, 2015, , 80:117-122
[22]Saeid A, Chojnacka K.Toward production of microalgae in photobioreactors under temperate climate. [J].Chemical Engineering Research and Design,, 2015, 93:377-391
[23]Soletto D, Binaghi L, Ferrari L, et al.Effects of carbon dioxide feeding rate and light intensity on the fed-batch pulse-feeding cultivation of Spirulina platensis in helical photobioreactor[J].Biochemical Engineering Journal, 2008, 39(2):369-375
[24]Zeng A B, Zhu J L, Zhao X K, et al.Comparison of salt-tolerance and genetic evolutionary analysis for five isolates of Spirulina platensis from contrasting ecological environments[J].Fresenius Environmental Bulletin, 2013, 22(6):1697-1709
[25]Zhang L L, Chen L; Wang J F, et al.Attached cultivation for improving the biomass productivity of Spirulina platensis. [J].Bioresource Technology, 2015, 181:136-142
[26]Zhou X P, Yuan C, Chen R C, et al.Sustainable production of energy from microalgae: Review of culturing systems,economics,and modelling[J].Journal of Renewable and Sustainable Energy, 2015, 7(1):A-r
|
|
|
|
